加入收藏
網站地圖
您現在所在的位置：首頁 > 新聞中心
潛水射流曝氣機
發布者：admin 點擊：0
我公司專業生產銷售氣浮機刮吸泥機氣浮氣浮設備砂濾罐本文由www.oliedu.cn提供
射流在高速前進過程中，在分散器內高速旋轉的作用下，具有較高的角速度，使射流具有較強的穿透力，使微小氣泡在水中氣浮行程遠，增強攪拌、推流與增氧能力。
本設備能使泥水與空氣在射流器內產生較高的負壓和強烈的紊動、攪拌、剪切，促使液膜與氣膜高頻振蕩，負氣泡直徑大幅度減小，氣浮數量增多，增大氣泡的比表面積，同時也負氣液膜變薄，能極大地降低傳質阻力，使氧分子更好地從氣相轉移到液相。
運行時，水泵葉輪在潛水電機帶動下高速旋轉，將泥水混合物推入射流器形成射流，在射流附近產生負壓區，將空氣通過吸氣管吸入射流噴嘴負壓區，在射流器的喉管內進行氣、水、泥充分混合，又通過射流器的擴散管將射流的動能逐步轉變成壓能后進入散流器。在散流器內，氣、水、泥混合物進一步混合，迫負氣體繼承剪切、破碎摧毀并氣浮，絕大部門氧充分溶解于水中。同時，在射流流體壓力的作用下，射流攜帶氧分子和微小氣泡，從散流器的噴嘴中傾斜向下噴出、擴散，形成對水體和對生化池底部污泥沖擊、攪拌后，由池底緩緩上升至水面，微氣泡在水中停留時間一般長達30秒以上，使空氣中的氧充分被溶解和吸收，進步了氧轉移效率和充氧能力。
潛水射流曝氣機由潛水泵、射流器、散流器、吸氣管和軟管五部門組成，如下圖所示。在傳統射流機理基礎上融合了提高前輩的散流技術，采用射流曝氣方式。
Jet in high speed process, under the action of the distributor in the high speed rotating, has the high angular velocity, jet has strong penetrating power, visit the tiny air bubbles in water, enhance stirring, pushing flow and aerobic capacity.
This equipment can make the muddy water and air to produce high negative pressure in the jet device and strong turbulence, mixing, shearing, prompting liquid film and gas film high-frequency oscillation, greatly reduce the diameter of bubble, bubble number increase, increasing the specific surface area of bubbles, and at the same time just stubbornly thin liquid film, can greatly reduce the mass transfer resistance, better make oxygen from gas phase to the liquid phase. Running, the water pump impeller under the submersible motor drive at high speed, push the mud mixture into the jet formation of jet, the negative pressure zone, near the jet of air through the suction jet nozzle negative pressure zone, the jet flow within the pipes, gas, water, mud mix, and through the diffusion of jet pipe jet kinetic energy into pressure energy gradually after entering the diffuser. Within the diffuser device, gas, water and mud mixture mixing, further forced negative gas inheritance shearing, crushing destroy and emulsification, ensure that the department fully dissolved oxygen in water. At the same time, under the action of jet fluid pressure, jet carrying oxygen molecules and the tiny bubbles and tilted downward from the nozzle to the scattered jet, diffusion, formation of water body and the impact of biochemical bottom sludge, mixing, from the bottom up gently to the surface of the water, tiny air bubbles in the water residence time is generally more than 30 seconds, make the oxygen in air was dissolved and absorbed adequately, advances the oxygen transfer efficiency and oxygen filling ability. Diving jet aerator composed of submersible pump, jet, diffuser, air suction pipe and hose of five departments, as shown in the figure below. On the basis of traditional jet mechanism combines improve predecessors diffuser technology, adopts the jet aeration method.
蘇公網安備 32020502000117號